SR-71 Blackbird

SR-71 pilot explains how to get better gas mileage in a Blackbird flying at Mach 3

SR-71, KC-135Q and JP-7

The SR-71 Blackbird would be a very short-ranged aircraft were it not for air refueling, limited to around 2,000 NM. Multiple air refuelings extended the range of the aircraft to the limits of crew endurance. Many missions have exceeded 12,000 NM. Forward basing of the SR-71 and KC-135Q tankers permitted faster response, shorter range, shorter duration missions, fewer air refuelings, and greater overall efficiency.

CLICK HERE to see The Aviation Geek Club contributor Linda Sheffield’s T-shirt designs! Linda has a personal relationship with the SR-71 because her father Butch Sheffield flew the Blackbird from test flight in 1965 until 1973. Butch’s Granddaughter’s Lisa Burroughs and Susan Miller are graphic designers. They designed most of the merchandise that is for sale on Threadless. A percentage of the profits go to Flight Test Museum at Edwards Air Force Base. This nonprofit charity is personal to the Sheffield family because they are raising money to house SR-71, #955. This was the first Blackbird that Butch Sheffield flew on Oct. 4, 1965.

KC-135Q crews and their aircraft were unique from the rest of the Air Force in several ways. Their aircrews in fact were the only one certified in Blackbird’s specific radio-silent rendezvous procedures, and their boom operators were the only ones qualified to refuel the SR-71. The Q-model tankers had special plumbing between their fuel tanks, allowing them to transfer JP-4 and JP-7 fuel between various tanks. Their engine could burn transfer JP-4 or JP-7 fuel. If the SR-71 landed somewhere JP-7 fuel was not available, the Q-model tankers flew in with the fuel and, through the use of transfer hoses on the ground, were able to refuel the SR-71.

How to get better gas mileage in an SR-71 Blackbird flying at Mach 3

David Peters, former SR-71 pilot, explains how to get better gas mileage in a Blackbird flying at Mach 3;

David Peters in SR-71’s cockpit

‘We had some gimmicks we used to make fuel. Each plane was different but the techniques were very close. As soon as we started the climb away from the tanker I would select tank two manually and even sometimes go to manual aft transfer to get the CG aft as soon as possible. After level off at Mach 3 I would get the CG situated where the trim was at zero for a slight cruise climb thus eliminating induced drag. Next I would have the aft doors in A position and manipulate the speed to close the forward doors as much as by possible without creating an unstart. This might be anywhere from 3.0 to maybe as high as 3.04 or 5.

‘Much of this was dependent on outside temperature. If it was colder than standard you could do even better. Hotter than standard not so good but always better than the plan. Using these techniques and a few more I would often see fuel flows below 3600 lbs/hr/per engine at Mach 3. Ed and I rarely came back from a mission with less than 5,000 lbs more fuel than the flight plan called for. There are a lot of those things involved. Flying the SR required a great deal of stick and rudder abilities under some circumstances but I always told people it was primarily a cerebral machine. You had to have very deep understanding of how it worked to get the job done.’

This print is available in multiple sizes from AircraftProfilePrints.com – CLICK HERE TO GET YOURS. SR-71A Blackbird 61-7972 “Skunkworks”

Skill and knowledge

Peters concludes;

‘I have said many times before, much to the contrary of the engineers that DAFICS [digital automatic flight and inlet control system] really screwed up what the airplane was capable of just like everything we seem to do anymore it took the skill and knowledge of the operator pretty much out of the equation. But that is another discussion.’

Be sure to check out Linda Sheffield Miller (Col Richard (Butch) Sheffield’s daughter, Col. Sheffield was an SR-71 Reconnaissance Systems Officer) Twitter X Page Habubrats SR-71 and Facebook Page Born into the Wilde Blue Yonder Habubrats for awesome Blackbird’s photos and stories.

This model is available in multiple sizes from AirModels – CLICK HERE TO GET YOURS.

Photo credit: David Peters and TSgt. Michael Haggerty / U.S. Air Force

Linda Sheffield Miller

Grew up at Beale Air Force Base, California. I am a Habubrat. Graduated from North Dakota State University. Former Public School Substitute Teacher, (all subjects all grades). Member of the DAR (Daughters of the Revolutionary War). I am interested in History, especially the history of SR-71. Married, Mother of three wonderful daughters and four extremely handsome grandsons. I live near Washington, DC.

Recent Posts

The K-19, the first Soviet nuclear-powered strategic missile submarine that experienced a reactor failure on the first missile-firing voyage

The K-19 Project 658 (NATO reporting name Hotel I-class) K-19, the first Soviet nuclear-powered strategic… Read More

14 hours ago

USAF F-16 Pilot explains why a Viper is more comfortable than a commercial airplane for long-haul flights

Fighter pilots Utilizing extraordinary skill and precision, fighter pilots push their aircraft’s limits with complete… Read More

14 hours ago

US Navy EA-18G Growler pilot explains why pulling 9Gs feels like an elephant is standing on your chest (and it very quickly begins damaging your body)

G-LOC G-induced Loss Of Consciousness (abbreviated as G-LOC) is a term generally used in aerospace physiology to… Read More

2 days ago

US Navy F-4 RIO recalls when his Phantom II was mistakenly shot down by a US Navy F-4 (flown by a USAF exchange pilot)

The F-4 Phantom II In response to Navy requirements for a high-altitude interceptor to defend… Read More

2 days ago

US Navy A-7 pilot recalls taking his Corsair II as high as possible during Post Maintenance Check Flights

The Corsair II The A-7 Corsair II was initially developed in response to a 1963… Read More

3 days ago

USAF F-16 pilot tells why the F-15E Strike Eagle can’t hold a candle to an F-22 Raptor in an up close and personal engagement

F-15E Vs F-22 Developed to meet the US Air Force (USAF) requirement for air-to-ground missions, the… Read More

3 days ago