Losses and Aviation Safety

Former Blackbird pilot tells the story of one of only two successful SR-71 Barrier Engagements ever made

“There were only two barrier engagements recorded at the time, and fortunately, ours was the successful one,” Colonel (Ret) James H. Shelton Jr., former SR-71 pilot.

Colonel (Ret) James H. Shelton Jr. spent over nine years at Beale Air Force Base (AFB), six years flying the SR-71. He was the fifth SR-71 crewmember to reach the 900-flying hour plateau. Most commercial airline pilots would consider that a paltry amount of flying time, but few Habus ever reached that milestone.

Shelton remembers a unique operational Blackbird mission that occurred on his initial overseas deployment with Major Tom Schmittou (RSO) to Kadena AB in May 1969 in Richard H. Graham’s book SR-71 Blackbird Stories, Tales and Legends:

“The operational tasking from SAC headquarters always had maintenance personnel generating a primary and secondary aircraft. On 13 June 1969, we were in primary aircraft #979 for an operational mission over North Vietnam. It was a typical four-hour flight, consisting of a single east-to-west pass across Hanoi, air refuel over Thailand, then a west-to-east pass just south of Hanoi, returning to Kadena AB.

This print is available in multiple sizes from AircraftProfilePrints.com – CLICK HERE TO GET YOURS. SR-71A Blackbird 61-7972 “Skunkworks”

“The engine start, takeoff, air refueling, and acceleration to Mach 2.8 at an altitude of 77,000 feet went as planned. At the navigation checkpoint, Tom informed me that the navigation system was drifting and the mission should be aborted. Tom made the abort call, and I turned the aircraft back to Okinawa. The descent from altitude and approach for landing was normal. Moderate rain was falling, so I applied the rain remover fluid to the front windscreen, allowing me to see the runway about 2 to 3 miles out.

“The touchdown on the runway went smoothly. However, as I retarded the throttles to idle, the cockpit began to fill up with fog (water vapor). I had forgotten to increase the cockpit temperature to 85 degrees or higher, to prevent the formation of cockpit fogging. I remembered one pilot had previously blown the canopy off on landing just to see the runway. I really didn’t want to do that! I quickly flipped the cockpit temperature switch from automatic to manual hot. This eliminated the fog in the cockpit, but did nothing to slow the aircraft down. Being so engrossed with holding the temperature switch in the full hot position (spring-loaded), thereby fixing one problem, I inadvertently created another: I forgot to deploy the drag ‘chute.

The drag ‘chute must be deployed to slow the aircraft on landing, especially on a wet runway. In my mind, and in actuality, the aircraft was slowing enough. I applied the brakes and the antiskid started cycling like crazy, so I turned it off, but to no avail. I then shut down one engine as I saw the end of the runway coming up very, very quickly (at about 120 miles hour). Fortunately, the runway at Kadena had a cable barrier installed about 1,000 feet from the end, specifically for the SR-71.”

As Graham explains “the BAK 11/12 barrier was installed at two of our operating locations – on runway 16 at Beale and on runway 05R on Kadena. The barrier was designed to stop the plane at a maximum speed of 180 knots. Arming and disarming the barrier was controlled in the tower. At both Kadena and RAF Mildenhall, we had a crewmember in the tower during all takeoffs and landings to make sure everything went smoothly.

“When armed, the barrier was activated by the aircraft nosewheel and main gear as they rolled over pressure-sensitive switchmats located in the runway before the arresting cable. The switches energized a timing computer that caused the arresting cable to be thrown up to engage the main gear struts. On engagement, the arresting cable was pulled out with a relatively constant restraining force to stop the aircraft within 2,000 feet. This was all theoretical. In actual practice, the number of unsuccessful SR-71 engagements far outnumbered the successful ones. Besides Jim successful engagement, I know of only one other.”

Shelton continues. “The barrier is designed to pop up in front of the two main landing gear and stop the aircraft in 400 to 500 feet. The barrier unit uses the B-52 aircraft brake system to slow the aircraft and bring it to a stop (hopefully!). Boy, was I relieved that the barrier worked as advertised! There was one unsuccessful barrier engagement on 10 October 1968 at Beale, where the SR-71 (#977) was destroyed. There were only two barrier engagements recorded at the time, and fortunately, ours was the successful one.

“Well, I just knew my SR-71 flying days were over as I climbed out of the aircraft. This incident terminated my flying at Kadena AB for this tour. The maintenance personnel worked the rest of the day and all through the night replacing the gear doors, hydraulic lines, and electrical wires on the main landing gear damaged by the barrier cable. I owe a big thanks to those maintenance personnel, because the aircraft was ready to fly the next day. They sure saved my six o’clock position (butt).

“Since this was the second fogging incident, Lockheed designed a lever that the RSO moved to stop air from entering the cockpit before landing, eliminating any chance of fogging the cockpit as the throttles were retarded. I call that handle the “Shelton lever.” Needless to say, I was allowed to continue flying, thanks to the thorough flying evaluation the standardization crews administered to me on my return to Beale AFB.”

This model is available from AirModels – CLICK HERE TO GET YOURS.

Photo credit: U.S. Air Force

Artwork courtesy of AircraftProfilePrints.com

Dario Leone

Dario Leone is an aviation, defense and military writer. He is the Founder and Editor of “The Aviation Geek Club” one of the world’s most read military aviation blogs. His writing has appeared in The National Interest and other news media. He has reported from Europe and flown Super Puma and Cougar helicopters with the Swiss Air Force.

Recent Posts

US Navy A-7 pilot recalls taking his Corsair II as high as possible during Post Maintenance Check Flights

The Corsair II The A-7 Corsair II was initially developed in response to a 1963… Read More

9 hours ago

USAF F-16 pilot tells why the F-15E Strike Eagle can’t hold a candle to an F-22 Raptor in an up close and personal engagement

F-15E Vs F-22 Developed to meet the US Air Force (USAF) requirement for air-to-ground missions, the… Read More

9 hours ago

Oregon Air National Guard 142nd Wing unveils first two operational USAF F-15EX Eagle II fighter jets

Oregon Air National Guard 142nd Wing first two F-15EX Eagle IIs On Jul. 12, 2024… Read More

1 day ago

F-104 Starfighter Pilot recalls when he and his Wingman scored five Simulated Kills against an F-15B Eagle in a Single Training Mission

The F-104 Starfighter Designed by Lockheed’s ace engineer Clarence “Kelly” Johnson to surpass the MiG-15… Read More

1 day ago

USAF A-10 pilot recalls his job as “Snacko” (Snack Officer) when he got to his first operational squadron

The Snacko In US Air Force (USAF) flying squadrons are busy places. According to BogiDope.com,… Read More

2 days ago

From damaged neck discs to being momentarily incapacitated during a dogfight: US Navy fighter pilot tells how high Gs over many years damaged his body

G-LOC G-induced Loss Of Consciousness (abbreviated as G-LOC) is a term generally used in aerospace physiology to… Read More

2 days ago